Vol. 20, No. 2, pp. 111-119 (2024)
STUDY ON THE IMPACT CUSHIONING PERFORMANCE AND
STRUCTURAL OPTIMIZATION OF A MODULAR COMPOSITE BUFFERING STRUCTURE
Yun-Tao Jin 1, 3 and Zhi-Xiang Yu 1, 2, 3, *
1 School of Civil Engineering, Southwest Jiaotong University, Chengdu 610031, China
2 National Engineering Laboratory for prevention and control of geological disasters in land transportation,
Chengdu 611756, China
3 Research Center of Protection Structures Against Natural Hazards, Southwest Jiaotong University,
Chengdu 610031, China
*(Corresponding author: E-mail:This email address is being protected from spambots. You need JavaScript enabled to view it.)
Received: 8 April 2024; Revised: 13 May 2024; Accepted: 5 June 2024
DOI:10.18057/IJASC.2024.20.2.2
 View Article |
Export Citation: Plain Text | RIS | Endnote |
ABSTRACT
The traditional concrete rockfall shed, relying on a sand cushion for impact energy absorption, suffers from limited buffering performance, long recovery cycles, and inadequate resilience in emergency disaster prevention. To address these issues, this paper proposes a modular composite buffering structure comprising a flexible steel buffer and a sand cushion. A 500kJ impact test was conducted on the structure to investigate its mechanical behavior and rockfall cushioning performance. The test revealed the energy dissipation mechanism between the flexible steel buffer and the sand. Using the LS-DYNA platform, a FEM-DEM coupled dynamic numerical model was established to compare the cushioning performance of the buffering structure with other typical cushions. Additionally, the supports under the concrete slab and the structural layout of the flexible buffer were optimized to achieve better buffering and structural perfoemance. The research demonstrates that the composite buffering structure exhibits excellent cushioning performance, remaining intact under 500 kJ impact. Compared to sand material and EPS-sand cushion, the composite buffering structure reduces impact force by 62% and 20%, respectively. After replacing the supports under the slab by buckling corrugated tubes, the composite system is able to bear 1000kJ impact and the slab’s bearing capacity is improved. With its superior cushioning performance, the composite buffering structure shows great potential for engineering applications.
KEYWORDS
Steel rockfall shed, Rockfall impact, Flexible steel structure, Energy absorption, Buckling corrugated tubes
REFERENCES
[1] Yu Z.X., Zhao L., Liu Y.P., Zhao S.C. Xu H. and Chan S.L., Studies on flexible rockfall barriers for failure modes, mechanisms and design strategies: a case study of Western China, Landslides 16(2), 347-362, 2018.
[2] Volkwein A., Schellenberg K., Labiouse V., Agliardi F., Berger F., Bourrier, Dorren L.K.A., Gerber W. and Jaboyedoff M., Rockfall characterisation and structural protection –a review, Natural Hazards and Earth System Sciences, 11(9), 2617-2651, 2011.
[3] Luo G., Cheng Q., Shen W., Ling S., Zhang X., Zou P. and Zhao Y., Research Status and Development Trend of the High-Altitude Extremely-Energetic Rockfalls, Earth Science 47(3), 913-934, 2022.
[4] Kishi N., Konno H., Ikeda K. and Matsuoka K.G., Prototype impact tests on ultimate impact resistance of PC rock-sheds, International Journal of Impact Engineering, 27(9), 969-985, 2002.
[5] Delhomme F., Mommessin M., Mougin J.P. and Perrotin P., Behavior of a structurally dissipating rock-shed: experimental analysis and study of punching effects, International Journal of Solids and Structures, 42(14), 4204-4219, 2005.
[6] Mougin J.-P., Perrotin P., Mommessin M., Tonnelo J. and Agbossou A., Rock fall impact on reinforced concrete slab: an experimental approach, International Journal of Impact Engineering, 31(2), 169-183, 2005.
[7] Pichler B., Hellmich C. and Mang H.A., Impact of rocks onto gravel Design and evaluation of experiments, International Journal of Impact Engineering, 31(5), 559-578, 2005.
[8] Kawahara, S. Muro T., Effects of dry density and thickness of sandy soil on impact response due to rockfall, Journal of Terramechanics, 43(3), 329-340, 2006.
[9] Shi S.Q., Wang M., Peng X.Q., Yang Y.K., A new-type flexible rock-shed under the impact of rock block: initial experimental insights, Natural Hazards and Earth System Sciences, 13(12), 3329-3338, 2013.
[10] Wu Y., He S.M., Li X.P. and Wang D.P., Dynamic response and optimization of an inclined steel rock shed by the graded energy dissipating method, Journal of Mountain Science, 16(1), 138-152, 2019.
[11] Castanon-Jano L., Blanco-Fernandez E., Castro-Fresno D. and Ballester-Muñoz F., Energy Dissipating Devices in Falling Rock Protection Barriers, Rock Mechanics and Rock Engineering, 50(3), 603-619, 2016.
[12] Qi X., Xu H., Yu Z.X. and Zhao L., Meng Q.C., Dynamic mechanical property study of brake rings in flexible protective system, Engineering Mechanics, 35(09), 198-206, 2018.
[13] Wang M., Shi S., Cui L., Liu Y. and Yang Y., Experimental investigation on three-bay and single-span flexible rock-shed under impact of rockfall, China Civil Engineering Journal, 51(5), 1-11, 2018.
[14] Tan K., Flexible Multi-body Dynamics Simulation of Cable-supported structure for rockfall protection, Southwest Jiaotong University, 2018.
[15] Chen F., Chen H., Structure optimization and calculation method of combined shed-tunnel structure, The Chinese Journal of Geological Hazard and Control, 31(1), 1-10, 2020.
[16] Yu Z.X., Zhao L., Guo L.P., Liu Y.P., Yang C. and Zhao S.C., Full-Scale Impact Test and Numerical Simulation of a New-Type Resilient Rock-Shed Flexible Buffer Structure, Shock and Vibration, 1-16, 2019.
[17] Zhang Y., Xie L.Z., He B. and Zhao P., Research on the Impact Force of Rockfall Impacting Sand Cushions with Different Shapes. Applied Sciences, 122, 2022.
[18] Wang Y.S., Xu M., Yang C., Lu M.Y., Meng J., Wang Z.L. et al. Effects of elastoplastic strengthening of gravel soil on rockfall impact force and penetration depth. International Journal of Impact Engineering, 136, 2020.
[19] Ouyang C., Liu Y., Wang D. and He S., Dynamic Analysis of Rockfall Impacts on Geogrid Reinforced Soil and EPS Absorption Cushions, KSCE Journal of Civil Engineering, 23(1), 37-45, 2018.
[20] Ertugrul O.L., Kiwanuka A., Dynamic analysis of rock fall impact for a cantilever rock shed with geofoam cushion, European Journal of Environmental and Civil Engineering, 27(5), 1989-2014, 2022.
[21] Sun J., Chu Z., Liu Y., Luo W. and Wang M., Performance of Used Tire Cushion Layer under Rockfall Impact, Shock and Vibration, 1-10, 2016.
[22] Wang D.P. , Bi Y.Z. , Zhou L., Chen H., Zhou R. and Lovati M., Experimental study on physical model of waste tennis ball-sand composite shed cushion under rockfall impact, Bulletin of Engineering Geology and the Environment, 81(5), 2022.
[23] Mentani A., Giacomini A., Buzzi O., Govoni L., Gottardi G. and Fityus S., Numerical Modelling of a Low-Energy Rockfall Barrier: New Insight into the Bullet Effect, Rock Mechanics and Rock Engineering, 49(4), 1247-1262, 2015.
[24] Zou P., Design of Modular Steel Structural Flexible Shed and Research on its Anti-impact Performance, Southwest Jiaotong University, 2021.
[25] EOTA, Falling rock protection kits, European Assessment Document, 2018.
[26] Zhong H.Q., Yu Z.X., Zhang C., Lyu L. and Zhao L., Dynamic mechanical responses of reinforced concrete pier to debris avalanche impact based on the DEM-FEM coupled method, International Journal of Impact Engineering, 167, 104282, 2022.
[27] Xu H., Gentilini C., Yu Z.X., Qi X. and Zhao S.C., An energy allocation based design approach for flexible rockfall protection barriers, Engineering Structures, 173, 831-852, 2018.
[28] Yu Z.X., Liu C., Guo L.P., Zhao L. and Zhao S.C., Nonlinear Numerical Modeling of the Wire-Ring Net for Flexible Barriers, Shock and Vibration, 1-23, 2019.
[29] Jin Y.T., Yu Z.X., Guo L.P., Luo L.R., Zhang L.J. and Liao L.X., Tensile-bending stiffness coordinated model for wire-ring nets in flexible rockfall protection system, Chinese Journal of Rock Mechanics and Engineering, 42(3), 698-707, 2022.
[30] Liu C., Theory and method of discrete analysis for flexible protective structure against geological hazard on shallow Slope, Southwest Jiaotong University, 2020.